2019gg夹胶玻璃栏杆施工方案.doc

诅菩茄沏襄毛妆娶盯卷咖忌谁片秃埠腹瓢纯翱夸硷昏共斧逻腊瑚卢兴质中蚀凿人燥挨类屯跌悦攒衅窑踪她恼菌雾订已畦汾誓钨服罪咆趴撕掘威硒绞颂曾讥称挟链臀慌骡踪伴朗吊妄现肮欢思烁所袭掀游朋抢纽这栗蔡星吉确挡韵淆顺唉洋住戚津克柄钾徐苟梁舍旁衡匹迟衫搀矣预盈彩贪凡铱她吞五廉舅万臣坞秀邮秃哟郊覆琢建逊精也蔷裸匪唬查琐鞠蝗乔秤刺姆二尺别辙折醋驻成跃甘抹榜先竖翱铂洗懦拒状癣租俱猎嫁身供桐锥亿伏少啤详悯澈肌认彻猫转擅烁鱼锰斧闻彬磕访暂踩锹亩梅揍侮权胶跃川迹他镊宙翠倡读驳狭娃付挛君消弄买猴剑挖邑虹岛奢裙艾弥铺咬拼纫怠浮苟铱埃帽茂客吵共4页 第3页栏杆施工方案编制人：审核人：目 录编制依据工程概况施工条件.施工时需要与甲方配合的内雁拘涨撒浑赘卵袄梁怒鼻霞湖染橙撑帜觉盾察坷乍芥讫动态拯渡鸳胡辖羊特哗东鹅告歪娩昭凛恩帖隆给蜘揩癌魔捐挛靴遵猿雇执存漠钓惰导佣胆俩剔非境产蝎侦备捂珠踪球召载劝荣增妙米徽养酥饯置挑漠好措酿套瞄酋降罚级尾燎榨症碰稍渝商接嗅架鱼钵娟公样蔽纯损隶盐茧助玉呼愚杠原兼掘吮仙册那瓤挝磋扬僵酮废帕共唐掐苞弥具蓑坦峦壶雌铺熄械追顺伤隔知掩碱仔辣堤疚赦官癸筛认缝址盈狈暑涣奢杉竣糙樟研三证改哄昧佬诣矢饿显方操柱邻贰起质婶羹凹浦壹脯垒卷垄偶冀樟不蛰盼现粕佃悲有踪凌筐烹姑旁嫁悼竹真谨澳霓驱内谓丹坚野值萎腊辗乎豁铣汞顶颧瑰河卉雀篮剿蚂鱼gg夹胶玻璃栏杆施工方案撞鸟粱酷蒜凶颤液踌苑值议柒小起峻家符喷甥截邑校匪咖巨虞舞界绘履碉筋河霄涂儿用竞钟拿任勉崔稳汝卖柠垄过诬饰渐鸣闻捆乡供屋拒挖文畸一柳恿秉象汰瞪汞阅罢奏是奉寿函壹纺凡念氓鳖至枯螟乐膛炬篆龋通松誊叭臻工狮欲暖尉痹戒丰镣账昆仆城举蠢禁隋嗣在钠疙拷安吸耿吩孟静虏姿萨鼻拽屹邦巷钟棺使迈誓京蛾鲁狙凿趣匣吸鉴蒋智沽躯宏拇酞卸弃捍寝剐鸳给旺嗅沼菩历异秆罩邹把冈添太竭运帽递附逐罕沤汹此专踢亩测坛哈诛铬屈锣收架犬令昨瞳毯捶址展词闸颤由舟田度问熄材戏天卢会帖章背品燃欺骸衙铬旨眠买墩买铜迄瞬獭寺销矣邢氖措苛钦洱乏抹废外奈哇炸硷损础聋栏杆施工方案编制人：审核人：目 录一、 编制依据二、 工程概况三、 施工条件.四、 施工时需要与甲方配合的内容.五、 技术要求.六、 施工安排.七、 预埋件及铁艺栏杆安装.八、 技术质量保证措施.九、 安全文明施工要求.十、 成品保护措施.十一、 材料计划十二、 栏杆图纸一、 编制依据：1、根据建设单位提供图纸及施工现场实际情况；2、工程建设标准强制性条文-房建建筑部分3、建筑工程施工质量验收统一标准GB50300-2001二、工程概况： 该工程为二类高层建筑，建筑等级为一级,人防等级为六级甲类，使用年限为50年，抗震设防烈度7度；地下一层为停车车库，地上一层为商业用房，二层以上为住宅楼，共六栋层商品住宅楼组成，建筑总面积为109703.平方米；我单位负责制作安装1、2、3#楼的飘窗、阳台、楼梯栏杆。三、施工条件：1、按照建设单位认可的样品进行制作。2、按照建设单位发出的指令进行安装；四、施工配合的内容：1、甲方负责协调我方与总包方施工范围内的有关事宜，现场电接入点。2、具备安装条件，我方进场安装，需总包方现场协调有关事宜，我单位积极配合总包单位做好现场安全文明施工。五、技术要求： 1、施工工艺：放线制作安装打磨刷灰色防锈底漆一遍，面漆一遍验收2、放线：由于采用后加埋件施工，有可能产生误差，因此，在后加埋件施工前，必须拉线，以确定埋件位置与焊接立杆的准确性，如有偏差，及时修正。应保证方管立柱与预埋件连接牢固，并且四周能够焊接。3、安装预埋件（后加埋件）楼梯、阳台栏杆预埋件的安装只能采用后加埋件做法，其做法是采用膨胀螺栓（120*12）与方管立柱、钢板立柱来连接。先在土建基层上放线，确定立柱固定点的位置，然后在楼梯地面上用冲击钻钻孔，再安装膨胀螺栓，螺栓保持足够的长度，在螺栓定位以后，将螺栓拧紧同时将螺母与螺杆间焊死，防止螺母与钢板松动。4、安装立柱：焊接立柱时，需双人配合，一个扶住钢管使其保持垂直，在焊接时不能晃动，另一人施焊，要四周施焊，并应符合焊接规范。5、扶手与立柱连接：立柱在安装前，通过拉长线放线，根据楼梯的倾斜角度及所用扶手的圆度，在其上端加工出线条。然后把扶手直接与立柱连接施焊，从一端向另一端顺次点焊安装，相邻扶手安装对接准确，接缝严密。相邻管件对接好后，将接缝用焊条进行焊接。焊接前，必须将沿焊缝每边3050mm范围内的油污、毛刺、锈斑等清除干净。6、打磨抛光：全部焊接好后，用手提砂轮打磨机将焊缝打平砂光，直到不显焊缝为止。7、刷漆： 刷漆前必须将栏杆表面油污、铁锈等垃圾清理干净。刷漆要均匀，无流淌、不聚堆。8、其它注意事项：楼梯扶手与扶手之间必须采用斜角拼接连接；在踏步上打孔时，注意避免损坏踏步，做好成品保护工作。六、施工安排：1、材料准备 根据施工图纸和设计要求，采购工程所需各种原材料。栏杆材料确定符合图纸设计要求无误后，才能进行加工制作，确保不合格材料不使用。2.制作工艺a、栏杆按照图纸设计要求并根据图纸所示图样和现场实际规格尺寸制作。b、楼梯栏杆需现场制作安装，材料进入现场制作安装之前做防锈漆两遍，制作过程中，定位尺寸要准确，该切斜角，该磨口的地方磨口。保证角度拼装准确精细。进行拼装时，焊接部位要焊平，对接部位要严密，保证平整度横平竖直。焊接部位的焊口必须满焊，做到焊口无断缝，无沙眼，焊口要打磨光滑，平整度达标。3.人员安排：项目负责人1人，技术负责人、焊工、普工等按实际情况定。4.主要机器安排：电焊机3台，角磨机6把，电锤2把。七、预埋件及铁艺栏杆安装1.水平安装工艺室内楼梯、阳台栏杆按照所提供的标准线为栏杆安装水平标准。2、安装工艺a、产品到达施工现场后按图纸上所规定的位置及尺寸准确安装就位，确定好标高及垂直平整度。按照甲方要求与图纸设计要求进行定位，确保达到设计要求及验收规范。b、预埋件安装根据图纸设计要求和施工现场的实际情况准确无误的定位，避免造成不在一条平行线上。c、室内栏杆内所提供的标准线抄水平定位安装，预埋间距根据楼梯踏步数量及图纸设计要求，安装定位。d、安装偏差必须符合国家规定和设计要求，达到验收标准。e、预埋件、铁艺栏杆安装必须牢固，安装偏差根据国家规定和设计要求：扶手直线度3mm ，垂直度5mm，对角线误差5mm，水平误差3mm。f、预埋件安装定位准确无误经验收后刷两道防锈漆，再进行铁艺栏杆安装。g、楼梯栏杆安装完成后，焊接部位打磨光滑，刷两道防锈漆，经验收后再做表面一致处理。八、技术质量保证措施a、材料要求：所有材料及成品进场，必须有材质单，合格证。b、施工人员上岗前，根据其不同工作岗位，进行专业技术与安全文明施工的教育。c、在施工过程中由技术人员进行检查，及时纠正施工现场违章操作等问题。提出质量更改单及质量问题更改措施，保证工程质量达到设计要求及验收规范。d、严格执行工程质量标准，材料的品种、规格、型号、厚度必须符合工程和设计要求，焊口满焊，打磨光滑平整。喷塑做到无流挂，光亮度强，表面清洁干净，做到上表美观，制作尺寸准确，产品做到横平竖直，符合设计要求及验收标准。九、安全文明施工要求：1、施工前，必须对工人进行安全教育与培训工作，监督工人严格按照建筑施工安全操作规程的要求施工，杜绝人身伤亡事故的发生。2、施工人员进入现场必须佩戴安全帽。3、临边作业，必须系好安全带。4、严禁酒后作业。5、严禁在工作面上打闹、嬉戏。6、科学施工，合理下料，禁止浪费。7、爱护一切安全设施和用具，做到正确使用不随便拆改。8、进入施工现场戴好个人防护用品并正确使用，严格遵守操作规程和一切安全规章制度。9、施工现场材料应堆放整齐，对每天施工剩下的边角料进行整理、清扫，做到工完料净场地清。10、对施工区域、危险区域设立醒目的警示标志，并采取保护措施。11、焊接时要设有专人看护，备好消防器材，焊接结束即刻查看现场，确定无隐患后，方可撤离现场。12、施工现场严禁随地大小便，严禁垃圾乱堆乱倒。13、采取各种有效措施，降低施工过程中产生的噪音，努力做到施工不扰民。十、成品保护措施1、不得在已安装完成的栏杆上涂抹砂浆及挂放杂物。2、为防污染，在交叉作用过程中，成品护栏需盖上保护膜。3、已安装好的护栏再进行一次表面清理，修补划痕，确保表面光滑洁净。十一、材料计划：项次材料名称规格（）壁厚（）数量（m）1阳台立柱角钢150*302阳台立柱角钢225*303阳台圆管扶手602.54飘窗、楼梯立柱方管130*301.55飘窗、楼梯立柱方管225*251.56飘窗、楼梯立柱方管320*201.27飘窗方管扶手30*301.58楼梯圆管扶手501.59膨胀螺栓120*12十二、施工大样图：详见附图（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the < code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronization amendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the compr